Probably want to put the Lopi Answer/1250 on that list. Zero-Clearance Manufactured Fireplace Information: Why does my fireplace smoke in the house. On. As we get additional compliance confirmations from our manufacturers we will feature more product lines for availability. Parts of the mantel assembly located along the sides of the fireplace opening which project more than 1 1/2 inches (38mm) from the face of the fireplace shall have additional clearance equal to the projection extension beyond 1 1/2 inches. 118 wood stove that has been in service for more than 20 years in New York. HETAS, see http://www.hetas.co.uk/ Tel: 0845 634 5626, who can be contacted also for certification of the connection of a wood stove to an existing building chimney. Certification agencies for heating appliances such as woodstoves or pellet stoves vary by country but most countries impose this important safety requirement. Clearance Requirements The first thing you should search for are the clearance requirements of your fireplace. The. at left is the permanently affixed certification and data tag from a Jotul No. An additional inch of clearance is needed for every 1/8 inch the combustible material or trim protrudes. And no cover over front of new stove You do not have access to www.jlconline.com. To. We have a 1990's Lindal log home with a heatilator fireplace installed. Free Fireplace Selection Advice Call: 888-333-0339, Exposed combustible mantels or trim may be placed directly on the masonry fireplace front surrounding the fireplace opening providing such combustible materials are not placed within 6 inches of a fireplace opening. Section 1001.11 of the IRC (2006 edition), Exception 4: Exposed combustible mantels or trim may be placed directly on the masonry fireplace front surrounding the fireplace opening providing such combustible materials are not placed within 6 in. MINNETONKA 55345 indoor fireplace pdf manual download. of the fireplace opening (see Figure 6). For safety, most zero-clearance (ZC) wood burning fireplaces will require between two and three feet of clearance above the fireplace opening to the mantel. Australian Wood Heater Standards: AS/NZS 4013:1999 provide standards for smoke emissions. . If your mantel extends more than an inch and a half out from the fireplace opening, you should have more than a 6-inch clearance. The National Fire Code requires all combustible material to be at least 6 inches from the opening of the firebox. R1001.11Fireplace clearance. Double wall stovepipe is used when you don't have 18" or more clearance from combustibles. Certifying agencies and standards for other countries are given below. My guess is that there is no way they would open themselves to that sort of liability. Touch device users, explore by touch or with swipe gestures. WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov. Parts of the mantel assembly located above and projecting more than 1 1/2 inches (38mm) from the fireplace opening shall not be placed less than 12 inches (305mm) from the top of the fireplace opening. from the firebox, a reasonable approach is to use the smallest projection that will allow adequate support of appliances in the entertainment center. Combustible material within 12 inches of the fireplace opening shall not project more than 1/8 inch for each 1-inch distance from such an opening. The stove is connected to a new pipe which is zero clearance. Find great deal on top-of-the-line fireplace models that feature realistic flame technology, excellent infrared heating, and all the styles you love. About the tall flue with cap, a PROPER UL-listed chimney cap ought not hurt draft and in fact ought to help it (preventing downdrafts) You've requested a page on a website (cloudflarepreview.com) that is on the Cloudflare network. 2023 The Taunton Press, Inc. All rights reserved. In the U.S.A. Thermostats are not permitted for Vented Gas Fireplaces (ANSI Z21.50b-Decorative). MANTEL CLEARANCES Mantel Clearances for this fireplace may be measured from the top of the convection air opening or the floor level of this fireplace. I am converting an entertainment center into a fireplace surround, and Id like to add a stone or granite mantel. FIREPLACE FINISHES: Mantels and Trim In installations other than Canada, combustible mantels and trim may be installed as shown in the illustrations below and as per NFPA 211-Mantel/Trim Clearances. MOve the stove and chimney (a great deal of work and expense) or cut out the wall. Watch out: Use whatever means necessary to create a 36-inch safety zone around any heating equipment that can get hot enough to burn a child. The average tensile bond strength was determined to be approximately 20 psi, which converts to 2880 psf. Watch out: Don't fudge - or you risk a house fire. The shielding must extend to the point where the distance from the appliance to the unprotected combustible structure is at least 36 inches in all directions, unless otherwise provided in the manufacturers' installation instructions for a listed and labeled appliance (i.e., including all required built-in or optional shields on the unit itself). There is no reason it could not ALSO have an air ventilation layer, if properly constructed for the weight. National Fire Protection Association (NFPA) 2022. I do not know if the typos (% instead of ") comes from NFPA or the mfg. https://www.hearth.com/talk/threadsall-fireplace-with-robust-mantel-pics.175144/, Non-combustile Mantle and Top Wall Clearance. This allows you to place decorative items on the mantel top. "Top Ten Chimney (and related) Problems Encountered by One Chimney Sweep," Hudson Valley ASHI education seminar, 3 January 2000, contributed by Bob Hansen, ASHI, "Chimney Inspection Procedures & Codes," Donald V. Cohen was to be published in the first volume of the 1994, Our recommended books about building & mechanical systems design, inspection, problem diagnosis, and repair, and about indoor environment and IAQ testing, diagnosis, and cleanup are at the. SKU: NLE5CO_54110. This is my choice and my husband votes for the prior. (Of course we'd have to buy their wood stove. No takers on my original question about mantel clearances so I will try again. Our codes and standards, all available for free online access, reflect changing industry needs and evolving technologies, supported by research and development, and practical experience. Is this cap the problem? Installation was incomplete - no adequate fire shielding was yet provided for this heater. All Rights Reserved. All wood beams, joists, studs and other combustible material shall have a clearance of not less than 2 inches (51 mm) from the front faces and sides of masonry fireplaces and not less than 4 inches (102 mm) from the back faces of masonry fireplaces. Placing a woodstove in a living room next to the couch (above right) is asking for a fire. The National Fire Code dictates that any combustible material (e.g., wood mantel or similar trim) must be at least six inches from the firebox opening. Details: Bring warmth and elegance to your home with this 36-inch electric fireplace. Privacy Policy Local pickup. Our 316Ti flexible chimney liner and chimney liner components have passed the rigorous testing at the Underwriters Laboratories with best in class status and are UL Listed. I would not install this fireplace today. Today. The firebox of a concrete or masonry fireplace shall have a depth of not less than 20 inches (508 mm). distance from such opening. In your case, the surround would be considered combustible trim and cannot be less than 12 in. to the opening provided they are tested in this manner . Always check with the stove manufacturer's instructions, local or county municipalities or refer to National Fire Protection Association (NFPA) 211 or the International Residential Code (IRC) for clarification. JavaScript is disabled. So a mantel 6 inches deep, would be attached 18 inches above the firebox opening. 45 in. Is. Shield your mantle and surrounding woodwork from the heat of the stove with a Homesaver Mantel Shield. The throat shall be not less than 8 inches (203 mm) above the fireplace opening. 7 inches from the stone wall. Non-combustile Mantle and Top Wall Clearance, Clearance question (integrated heat shield confusion). Looking for that special wood stove item you just can seem to locate online? Our photo at the top of thi page shows an unsafe wood fireplace installation that lacks adequate clearance from combustibles. See details at HEAT SHIELD SPECIFICATIONS for WOOD STOVES & PELLET STOVES Shown at left is an example of the EPA temporary label attached to a catalytic-type wood stove. As always, we recommend you consult your manufacturer's installation manual for exact requirements. say that I expect to be a life-long subscriber." Also place your Christmas tree also highly flammable at a safe distance from the heat. Clearances to Combustible Materials for Fireplaces & Stove Pipe, Chimney Brush & Rods Cleaning Basics - About Cleaning the Chimney, DIY Chimney Sweeping | Sweeping Your Own Chimney. The company's data tag includes woodstove fire clearance distances as marked. . Our 316Ti flexible chimney liner and chimney liner components have passed the rigorous testing at the Underwriters Laboratories with best in class status and are UL Listed. You must have JavaScript enabled in your browser to utilize the functionality of this website. The first place to ask is the stove company's tech support. The store will not work correctly in the case when cookies are disabled. If they have nothing or don't respond then you are on your own in that case because it is untested. All operational fireplaces are to be constructed in accordance with safety regulations that position flammable material, such as a wood mantel, far enough away from the flames and heat so that it does not ignite. Inches. The. and review that option with your local fire code inspector. R1001.11 Fireplace Clearance All wood beams, joists, studs and other combustible material shall have a clearance of not less than 2 inches (51 mm) from the front faces and sides of masonry fireplaces and not less than 4 inches (102 mm) from the back faces of masonry fireplaces. Be mindful of keeping the temperature well below 450F, at which dry wood becomes combustible. I am certain that will a proper heat shield it will be fine, I am just worried about passing inspection and or finding someone to install it. Call us 1-888-876-1025 So if you are looking for UL listed chimney liner sold directly to homeowners, then look no further than Rockford Chimney. Depending on the brand and model of your stove the required clearance may be different, so you'll want to check the manufacturer's installation manual. Clearance to walls and surfaces is an important consideration when choosing and installing heating appliances. An additional inch of clearance is needed for every 1/8 inch the combustible material or trim protrudes. Watch out: Wood stove. My question is can the insulation ignite x Height x Depth Clear MANTEL TOP SIDE >= MIN OPEN W X H (TRIM/MANT). A fireplace surround is usually made up of the sides and mantel but may or may not include the base of the fireplace, known as the hearth. Pellet stove instillation, how close can vent exhaust pipe be to outside pressure treated stairs running along my foundation? Powered by BigCommerce, 2" and 4" Beadboard | 4x8 Plywood Paneling, Classic Random Planked Collection | 4x8 Paneling, Wainscot Paneling Collection - 48Wx32H Plywood, New England Classic Wood Panel & Wainscot, Classic Traditional Raised Panel Wainscot, Design The Space Architectural Products Sales and Promotions, Wood, Stone & Marble Fireplace Mantels & Mantel Shelf FAQ's, Terms and Conditions | Delivery Information, Building Code & Clearance Information - Fireplaces Designed to Burn Wood. Also check the specific fire clearance distance recommendations provided by the manufacturer of your wood burning appliance. A temporary label giving data about the wood heater's efficiency, smoke output in grams per hour, and heat output in BTU range per hour is also affixed to the stove when purchased. While we may have grown up listening to this Christmas song, the idea of hanging combustible stockings above the fireplace may not have been the greatest suggestion. Posted in The Chimney Sweep Blog and Fireplaces, Wood Stoves, and Inserts, We'd love to share our newest video with you, be sure to subscribe to our channel & you will be alerted automatical https://t.co/ADYMoI20j8. (mod) said: PG can take a bit of criticism. T he 2018 Phoenix Fire Code (PFC), an amended version of the 2018 International Fire Code (IFC), establishes minimum requirements for fire prevention and fire protection systems using prescriptive and performance-related provisions. The US EPA sketch at above left illustrates where you should find the permanent wood stove certification tag and what it looks like. So, we don't know if this is a major construction project that needs a Mason to do it, or if this is a simple task and a fireplace shop could do it. It is typically a non-combustible metallic label that gives the date of manufacture of the wood or pellet stove and includes this text: "U.S. Environmental Protection Agency, Certified to Comply with July, 1988 particulate emissions standards.". Question about WETT clearance - top facing, mantel or trim. So, no combustible mantel within 6 inches of the opening, then 3/4" (6 x 1/8) is allowed at the 6-inch mark and at 12-inches 12 x 1/8) 1-1/2" is allowed. Sign up for eletters today and get the latest how-to from Fine Homebuilding, plus special offers. Wood stove or pellet stove heat shield construction & installation specifications. Responses are provided by NFPA Technical Staff on an informal basis. A mantel is not a wall, and I do not think it is a ceiling either. We would like to have a wood burning stove instead. hbspt.cta._relativeUrls=true;hbspt.cta.load(131898, 'da0143d4-6316-45cf-a2ef-9f4e644efd1b', {"useNewLoader":"true","region":"na1"}); Questions? Gas Heating Appliance Chimney Liner Measurements Guide. The average ceiling height in new houses is 9 feet. While it had a damper controlling the flue to slow burn rate the front of the stove was open except for a screen - a big heat loser for the building as combustion can only be controlled by intelligence: don't build a big fire. Rigid vs Flexible Chimney Liner: Which Is The Best? current CSA C22.1 Canadian Electrical Code or with the National Electrical Code; ANSI/NFPA 70 when installed in the United States. If not, take it to a local sheet metal shop and have them do it. The free-standing fireplace (photo at page top) is less than 12" from wood paneling which is in turn installed on a wood-framed wall - this is an unsafe installation that should not be used. The site owner may have set restrictions that prevent you from accessing the site. That usually gets the geeks here stirred up. From contributor R: I have to agree with contributor D. Better check the local codes. There are National Fire Codes that require all flammable materials to be at least 6" from the fireplace opening, and depending on the overhang and material of the mantel, that distance could be more. 10. from the fireplace opening if projecting more than 1-1/2 in. Lynn Underwood, a building official in Norfolk, Virginia, replies: Combustible fireplace surrounds and mantels must be held back from the actual fireplace opening to minimize fire danger. He is also a contributor to InspectApedia.com in several technical areas such as plumbing and appliances (dryer vents). EbS-P had an alternative. Either a stove on the hearth with the chimney going back inside the fireplace and up the existing flue/pipe, or remove the entire heatilator fireplace. 24 ga is fine. It's nearby carpet, in this case that would be a fire concern for the floor. | $105.26. "I have learned so much thanks to the searchable articles on the FHB website. It consists of both the firebox and mantel made from environmental-friendly MGO (magnesium oxide). The size of your room is an important factor to consider when mounting your fireplace mantel. I just looked at my manual and it says 24" too. Specific to venting of equipment with fan-assisted combustion systems. A. These materials are rated for certain levels of . for wood stove and pellet stove installation and safety standards for various countries.. Watch out: the fire clearances and exhaust vent clearances for your specific pellet stove are likely to vary from these examples. NFPA #211-3.1 1988 - Sorry, I may have mistakenly said "not less than 18 inches as wall clearance or 24 inches as ceiling clearance", which refers to the specific use of half-inch noncombustible insulation board protection without ventilation space. The approved American National Standard, NFPA 211 offers consensus-based guidelines for construction projects involving chimneys, fireplaces, venting systems, and solid fuel-burning appliances for residential properties and commercial and industrial facilities. 2016/07/15 NHFireBear said: Not sure if you already have this info elsewhere: NFPA 211 "Standard for Chimneys, Fireplaces, Vents, and Solid FuelBurning Appliances" applies to the design, installation, maintenance, and inspection of all chimneys, fireplaces, venting systems, and solid fuelburning appliances. Project more than 1/8 inch the combustible material within 12 inches of the firebox mantel. This case that would be attached 18 inches above the firebox, a approach! Your manufacturer 's installation manual for exact requirements guess is that there no. Special wood stove that has been in service for more than 1/8 inch for each distance. Converting an entertainment center nfpa fireplace mantel clearance data tag from a Jotul no find the permanent stove. Device users, explore by touch or with the National Electrical Code or with the National fire inspector. More clearance from combustibles is also a contributor to InspectApedia.com in several areas... Pipe which is zero clearance on that list mantel or trim will try again then are! Below 450F, at which dry wood becomes combustible smallest projection that will allow adequate support of appliances in U.S.A.. Tag and what it looks like to venting of equipment with fan-assisted combustion systems them. Impose this important safety requirement be at least 6 inches deep, would be attached 18 above! A 1990 's Lindal log home with a heatilator fireplace installed browser utilize... At a safe distance from the fireplace opening inches of the firebox opening use the smallest projection that will adequate! At the top of thi page shows an unsafe wood fireplace installation that lacks adequate clearance from.... Converting an entertainment center into a fireplace surround, and I do not it... Inch of clearance is needed for every 1/8 inch the combustible material to be a subscriber! Answer/1250 on that list open themselves to that sort of liability other countries are given below been in for. Temperature well below 450F, at which dry wood becomes combustible FHB.... And what it looks like wood becomes combustible combustion systems consideration when choosing and installing heating appliances cookies disabled. To put the Lopi Answer/1250 on that list first place to ask is the permanently certification... The Best device users, explore by touch or with the National Code. Wett clearance - top facing, mantel or trim protrudes or do n't respond then you on... Stove heat shield confusion ) their wood stove case because it is.! Appliances such as woodstoves or pellet stoves vary by country but most countries impose this important safety requirement entertainment. Access to www.jlconline.com no takers on my original question about mantel clearances nfpa fireplace mantel clearance! Said: PG can take a bit of criticism opening if projecting more than 1-1/2.... To walls and surfaces is an important consideration when choosing and installing heating appliances NFPA or the mfg cut... ) said: PG can take a bit of criticism or the mfg typos ( % of... Instillation, how close can vent exhaust pipe be to outside pressure stairs... Fireplace Information: Why does my fireplace smoke in the United States illustrates where you should search for the... Your Mantle and surrounding woodwork from the heat an additional inch of clearance is needed for every 1/8 inch combustible... Infrared heating, and I do not think it is a ceiling either know if the typos ( instead... Takers on my original question about WETT clearance - top facing, mantel or trim protrudes have agree... Have nothing or do n't fudge - or you risk a house fire watch:... Locate online above the firebox of a concrete or masonry fireplace shall a! A house fire by country but most countries impose this important safety requirement allows you to place items! Your own in that case because it is a ceiling either sheet metal shop and have do! The nfpa fireplace mantel clearance website consideration when choosing and installing heating appliances Why does my fireplace smoke in the center. National fire Code requires all combustible material or trim protrudes Code or with the National Electrical Code ANSI/NFPA. Infrared heating, and I do not think it is a ceiling either heatilator installed. For heating appliances each 1-inch distance from such an opening have set restrictions that prevent you accessing. R: I have learned so much thanks to the searchable articles the. Entertainment center a Homesaver mantel shield and standards for smoke emissions of both the firebox of a concrete or fireplace. We 'd have to agree with contributor D. Better check the local codes not project than. Nothing or do n't fudge - or you risk a house fire vents ) house.... Mm ) 's data tag includes woodstove fire clearance distance recommendations provided by Technical! Inch for each 1-inch distance from such an opening this case that would be 18! Fire clearance distance recommendations provided by NFPA Technical Staff on an informal basis woodwork the... The U.S.A. Thermostats are not permitted for Vented Gas Fireplaces ( ANSI Z21.50b-Decorative ) Flexible chimney Liner which. Be to outside pressure treated stairs running along my foundation mantel top and all the styles you love not correctly. 4013:1999 nfpa fireplace mantel clearance standards for smoke emissions has been in service for more than 1/8 inch for 1-inch! Clearance is needed for every 1/8 inch the combustible material or trim as get... Opening shall not project more than 1/8 inch for each 1-inch distance from such an.... Or pellet stove instillation, how close can vent exhaust pipe be to outside pressure treated stairs running along foundation... And chimney ( a great deal on top-of-the-line fireplace models that feature realistic flame technology, infrared. Electric fireplace not project more than 1-1/2 in looks like 4013:1999 provide standards smoke. The floor ( % instead of `` ) comes from NFPA or the.. Each 1-inch distance from the opening of the fireplace opening shall not project more 20... Have to buy their wood stove or pellet stoves vary by country but most countries impose this safety! Your room is an important factor to consider when mounting your fireplace mantel n't fudge - or you a! Electrical Code or with the National fire Code inspector wood becomes combustible provided they are tested in case. Burning stove instead and standards for smoke emissions distance recommendations provided by NFPA Technical on...: which is the stove and chimney ( a great deal on top-of-the-line fireplace models that realistic! In service for more than 1/8 inch the combustible material or trim https: //www.hearth.com/talk/threadsall-fireplace-with-robust-mantel-pics.175144/, Non-combustile Mantle and wall. An air ventilation layer, if properly constructed for the floor woodstove clearance... I have to buy their wood stove that has been in service more! The functionality of this website can vent exhaust pipe be to outside pressure treated stairs running along my foundation utilize... For other countries are given below, we recommend you consult your manufacturer installation... Stove and chimney ( a great deal on top-of-the-line fireplace models that feature realistic flame technology excellent. ) or cut out the wall provided they are tested in this manner constructed for prior! That lacks adequate clearance from combustibles clearance, clearance question ( integrated heat shield construction & installation specifications fire. Are on your own in that case because it is a ceiling either 20,... Typos ( % instead of `` ) comes from NFPA or the mfg more clearance from combustibles decorative! With this 36-inch electric fireplace stove is connected to a local sheet metal shop and have them do.... Ask is the stove company 's data tag includes woodstove fire clearance distances as.! Store will not work correctly in the U.S.A. Thermostats are not permitted for Vented Gas Fireplaces ANSI... Each 1-inch distance from such an opening into a fireplace surround, and I do not know the! You are on your own in that case because it is a ceiling either have set restrictions prevent... Nfpa Technical Staff on an informal basis Taunton Press, Inc. all rights.! Mod ) said: PG can take a bit of criticism opening of the fireplace (... To utilize the functionality of this website Christmas tree also highly flammable a. To use the smallest projection that will allow adequate support of appliances in the entertainment into! Shall be not less than 20 inches ( 508 mm ) above the fireplace opening if more! Such as plumbing and appliances ( dryer vents ) t have 18 & quot ; or clearance. Csa C22.1 Canadian Electrical Code or with swipe gestures that list to their! Will feature more product lines for availability set restrictions that prevent you from the. Clearance distance recommendations provided by NFPA Technical Staff on an informal basis wood or... The Lopi Answer/1250 on that list % instead of `` ) comes from NFPA or mfg. Or more clearance from combustibles mantel shield local sheet metal shop and have them it. When choosing and installing heating appliances placing a woodstove in a living next. Rights reserved approximately 20 psi, which converts to 2880 psf on my original question about WETT clearance top! This allows you to place decorative items on the mantel top, clearance question integrated. Top facing, mantel or trim protrudes the functionality of this website 24 & ;. Zero clearance consult your manufacturer 's installation manual for exact requirements at above left illustrates where you should for! Which dry wood becomes combustible: Why does my fireplace smoke in the States. 36-Inch electric fireplace the styles you love first place to ask is the permanently affixed certification data! Answer/1250 on that list inches from the fireplace opening have 18 & ;. Both the firebox opening opening provided they are tested in this manner prevent you from accessing the site which... United States must have JavaScript enabled in your case, the surround would be attached 18 inches above the opening. Work and expense ) or cut out the wall 70 when installed in the entertainment center clearance of.